C8 Temperature gauge/sensor problems
Moderator: RichardW
-
- (Donor 2022)
- Posts: 41
- Joined: 13 Aug 2019, 17:24
- Location: Basingstoke, UK
- My Cars: Citroen Xsara Picasso VTX 16V
Citroen C8 2.0HDi (Deceased) - x 4
C8 Temperature gauge/sensor problems
I know this topic is live elsewhere but my problem is somewhat different.
When I switch on, my temperature gauge goes to 130degrees along with warning lights etc. After a while, but not every time, the needle will flicker a couple of times between 130 and 100 and then go down to 90. Over the next few minutes, it will slowly sink to 50. On the odd occasion, it will start at 50!
If I switch off while the gauge displays 130, the fans will go on for a time.
I have changed the Coolant Temperature sensor twice in my one year of ownership and I know from RAC records that it has been changed before. The last one lasted almost three months.
The car in question is a 2005 2.0HDi Auto.
Regards,
John
When I switch on, my temperature gauge goes to 130degrees along with warning lights etc. After a while, but not every time, the needle will flicker a couple of times between 130 and 100 and then go down to 90. Over the next few minutes, it will slowly sink to 50. On the odd occasion, it will start at 50!
If I switch off while the gauge displays 130, the fans will go on for a time.
I have changed the Coolant Temperature sensor twice in my one year of ownership and I know from RAC records that it has been changed before. The last one lasted almost three months.
The car in question is a 2005 2.0HDi Auto.
Regards,
John
John
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
-
- Donor 2023
- Posts: 2625
- Joined: 24 May 2007, 10:11
- Location: poole dorset uk
- Lexia Available: Yes
- My Cars: C5 X7 2009 2.0 HDI VF7**************[VIN obfuscated, can be read by forum staff]
C4 2010 2.0 HDi Exclusive VF7**************[VIN obfuscated, can be read by forum staff] - x 378
Re: C8 Temperature gauge/sensor problems
Welcome to the forum/family John.
Post your Vin number as this will help those with greater knowledge than myself to help.
Do not worry your Vin will only be visable to forum Admins.
I have my Vin posted in my signature, so much easier, just post a question and Vin is there![Smile :)](./images/smilies/icon_smile.gif)
Post your Vin number as this will help those with greater knowledge than myself to help.
Do not worry your Vin will only be visable to forum Admins.
I have my Vin posted in my signature, so much easier, just post a question and Vin is there
![Smile :)](./images/smilies/icon_smile.gif)
- GiveMeABreak
- Forum Admin Team
- Posts: 37014
- Joined: 15 Sep 2015, 19:38
- Location: West Wales
- My Cars: C3 Aircross SUV HDi Flair Peperoncino Red (The Chili Hornet)
C5 X7 2.0 HDi Exclusive Mativoire Beige (The Golden Hornet)
C3 1.6 HDi Exclusive Aluminium Grey (The Silver Hornet)
C5 MK II 2.0 HDi Exclusive Obsidian Black
C5 MK I 2.0 HDi SX Wicked Red
Xantia S2 2.0 HDi SX Hermes Red
C15 Romahome White
XM 2.0 Turbo Prestige Emerald Green Pearlescent
XM 2.0 Turbo Prestige Polar White
XM 2.0 SX Polar White
CX 20 Polar White
GS 1220 Geranium Red
CX 2.4 Prestige C-Matic Nevada Beige
GS 1000 Cedreat Yellow - x 5648
Re: C8 Temperature gauge/sensor problems
Yes, we need the VIN as there were 6 variants of the 2.0 HDi engine
Please Don't PM Me For Technical Help
Marc
Marc
-
- (Donor 2022)
- Posts: 41
- Joined: 13 Aug 2019, 17:24
- Location: Basingstoke, UK
- My Cars: Citroen Xsara Picasso VTX 16V
Citroen C8 2.0HDi (Deceased) - x 4
Re: C8 Temperature gauge/sensor problems
I've put the VIN in the signature as suggested!
John
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
- GiveMeABreak
- Forum Admin Team
- Posts: 37014
- Joined: 15 Sep 2015, 19:38
- Location: West Wales
- My Cars: C3 Aircross SUV HDi Flair Peperoncino Red (The Chili Hornet)
C5 X7 2.0 HDi Exclusive Mativoire Beige (The Golden Hornet)
C3 1.6 HDi Exclusive Aluminium Grey (The Silver Hornet)
C5 MK II 2.0 HDi Exclusive Obsidian Black
C5 MK I 2.0 HDi SX Wicked Red
Xantia S2 2.0 HDi SX Hermes Red
C15 Romahome White
XM 2.0 Turbo Prestige Emerald Green Pearlescent
XM 2.0 Turbo Prestige Polar White
XM 2.0 SX Polar White
CX 20 Polar White
GS 1220 Geranium Red
CX 2.4 Prestige C-Matic Nevada Beige
GS 1000 Cedreat Yellow - x 5648
Re: C8 Temperature gauge/sensor problems
What about the Engine thermostat? Item 7 on the left diagram and 3 on the other? Part 133823
Also some water temp sensors on the aftermarket aren't up to much. Part 1338C1 (item 9 on the left and 6 on the right diagram).
Also some water temp sensors on the aftermarket aren't up to much. Part 1338C1 (item 9 on the left and 6 on the right diagram).
Please Don't PM Me For Technical Help
Marc
Marc
- white exec
- Moderating Team
- Posts: 7445
- Joined: 21 Dec 2015, 12:46
- Location: Sayalonga, Malaga, Spain
- My Cars: 1996 XM 2.5TD Exclusive hatch RHD
1992 BX19D Millesime hatch LHD
previously 1989 BX19RD, 1998 ZX 1.9D auto, 2001 Xantia 1.8i auto
and lots of Rovers before that: 1935 Ten, 1947 Sixteen, 1960 P5 3-litre, 1966 P6 2000, 1972 P6 2000TC, and 1975 P6B 3500S - x 1752
Re: C8 Temperature gauge/sensor problems
Agree with Marc's suspicion about the thermostat - it sounds like a sticking one, reluctant to initially open, then allowing a sudden volume of cool water through. Action should be gradual and progressive.
Cheap enough to replace; make sure it comes with a fresh gasket/O-ring.
Cheap enough to replace; make sure it comes with a fresh gasket/O-ring.
Chris
- moizeau
- (Donor 2022)
- Posts: 1580
- Joined: 12 Jan 2015, 16:08
- Location: France 36
- My Cars: 91 BX TZD Estate. Dead but loved
407 HDI 136 auto
C4 2l petrol coupé
2010 Dispatch III HDI 90
AND a 1980 Z1000ST
AND a 1983 GPz1100 inj
AND a 1995 Zephyr 1100
AND a 1980 Z650 (my moped) - x 315
Re: C8 Temperature gauge/sensor problems
Not sure about the thermostat because John states that it reads 130 degrees when first switched on? Could you confirm, John, whether the engine is running or just the ignition? If the engine is running, does it show the high temperature straight away on a cold engine? The symptoms that follow, however, do point to a sticky thermostat.
Pete
Notice the BX is still top the list but sadly gone
Notice the BX is still top the list but sadly gone
- white exec
- Moderating Team
- Posts: 7445
- Joined: 21 Dec 2015, 12:46
- Location: Sayalonga, Malaga, Spain
- My Cars: 1996 XM 2.5TD Exclusive hatch RHD
1992 BX19D Millesime hatch LHD
previously 1989 BX19RD, 1998 ZX 1.9D auto, 2001 Xantia 1.8i auto
and lots of Rovers before that: 1935 Ten, 1947 Sixteen, 1960 P5 3-litre, 1966 P6 2000, 1972 P6 2000TC, and 1975 P6B 3500S - x 1752
Re: C8 Temperature gauge/sensor problems
Agree, Pete. Faulty 'stat would not produce 130C with a cold engine. ![d'oh! #-o](./images/smilies/eusa_doh.gif)
![d'oh! #-o](./images/smilies/eusa_doh.gif)
Chris
-
- (Donor 2022)
- Posts: 41
- Joined: 13 Aug 2019, 17:24
- Location: Basingstoke, UK
- My Cars: Citroen Xsara Picasso VTX 16V
Citroen C8 2.0HDi (Deceased) - x 4
Re: C8 Temperature gauge/sensor problems
It is extremely unlikely that the fault is with the thermostat. The temperature gauge can display both ends of the range in seconds and has never physically overheated. Having stood overnight, it is not possible that the engine temperature could still be 130 degrees. The last two sensors were purchased from GSF and they did make sure it was the correct one for the car.
I recently drove over 100 miles with the gauge reading 130 most of the way then 50 for a period before going back to 130. As the needle flicks about at times, this points to something electrical. Does this system have an ECU?
I recently drove over 100 miles with the gauge reading 130 most of the way then 50 for a period before going back to 130. As the needle flicks about at times, this points to something electrical. Does this system have an ECU?
John
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
-
- Donor 2023
- Posts: 2625
- Joined: 24 May 2007, 10:11
- Location: poole dorset uk
- Lexia Available: Yes
- My Cars: C5 X7 2009 2.0 HDI VF7**************[VIN obfuscated, can be read by forum staff]
C4 2010 2.0 HDi Exclusive VF7**************[VIN obfuscated, can be read by forum staff] - x 378
Re: C8 Temperature gauge/sensor problems
If we assume the dash display is correct as it reads both ends of the scale, and thermostat would not give a reading ? then for arguments sake what is the cheapest option ?
- white exec
- Moderating Team
- Posts: 7445
- Joined: 21 Dec 2015, 12:46
- Location: Sayalonga, Malaga, Spain
- My Cars: 1996 XM 2.5TD Exclusive hatch RHD
1992 BX19D Millesime hatch LHD
previously 1989 BX19RD, 1998 ZX 1.9D auto, 2001 Xantia 1.8i auto
and lots of Rovers before that: 1935 Ten, 1947 Sixteen, 1960 P5 3-litre, 1966 P6 2000, 1972 P6 2000TC, and 1975 P6B 3500S - x 1752
Re: C8 Temperature gauge/sensor problems
Maybe remove the temp sensor, and immerse it in known-temp water, IGN on, and see what the gauge reads.
Chris
-
- (Donor 2022)
- Posts: 41
- Joined: 13 Aug 2019, 17:24
- Location: Basingstoke, UK
- My Cars: Citroen Xsara Picasso VTX 16V
Citroen C8 2.0HDi (Deceased) - x 4
Re: C8 Temperature gauge/sensor problems
I'm not sure whether you can see the videos as it's the first time I've ever done this.
They show the start-up of the vehicle. This was after standing overnight for more than 12 hours.
The vehicle is currently on its third coolant temperature sensor in just over a year.
John
Last edited by GiveMeABreak on 20 Aug 2019, 14:12, edited 1 time in total.
Reason: Fixed YouTube Links
Reason: Fixed YouTube Links
John
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
- GiveMeABreak
- Forum Admin Team
- Posts: 37014
- Joined: 15 Sep 2015, 19:38
- Location: West Wales
- My Cars: C3 Aircross SUV HDi Flair Peperoncino Red (The Chili Hornet)
C5 X7 2.0 HDi Exclusive Mativoire Beige (The Golden Hornet)
C3 1.6 HDi Exclusive Aluminium Grey (The Silver Hornet)
C5 MK II 2.0 HDi Exclusive Obsidian Black
C5 MK I 2.0 HDi SX Wicked Red
Xantia S2 2.0 HDi SX Hermes Red
C15 Romahome White
XM 2.0 Turbo Prestige Emerald Green Pearlescent
XM 2.0 Turbo Prestige Polar White
XM 2.0 SX Polar White
CX 20 Polar White
GS 1220 Geranium Red
CX 2.4 Prestige C-Matic Nevada Beige
GS 1000 Cedreat Yellow - x 5648
Re: C8 Temperature gauge/sensor problems
John - I've fixed the links, but you have not set the permissions correctly in Youtube. The videos are probably set to private. You need to make them available to anyone who has the link or set to public.
Please Don't PM Me For Technical Help
Marc
Marc
-
- (Donor 2022)
- Posts: 41
- Joined: 13 Aug 2019, 17:24
- Location: Basingstoke, UK
- My Cars: Citroen Xsara Picasso VTX 16V
Citroen C8 2.0HDi (Deceased) - x 4
Re: C8 Temperature gauge/sensor problems
I've reset them to Public. You should be able to view them now.
John
John
John
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
Xsara Picasso VTX 16V
VIN VF7**************[VIN obfuscated, can be read by forum staff]
- GiveMeABreak
- Forum Admin Team
- Posts: 37014
- Joined: 15 Sep 2015, 19:38
- Location: West Wales
- My Cars: C3 Aircross SUV HDi Flair Peperoncino Red (The Chili Hornet)
C5 X7 2.0 HDi Exclusive Mativoire Beige (The Golden Hornet)
C3 1.6 HDi Exclusive Aluminium Grey (The Silver Hornet)
C5 MK II 2.0 HDi Exclusive Obsidian Black
C5 MK I 2.0 HDi SX Wicked Red
Xantia S2 2.0 HDi SX Hermes Red
C15 Romahome White
XM 2.0 Turbo Prestige Emerald Green Pearlescent
XM 2.0 Turbo Prestige Polar White
XM 2.0 SX Polar White
CX 20 Polar White
GS 1220 Geranium Red
CX 2.4 Prestige C-Matic Nevada Beige
GS 1000 Cedreat Yellow - x 5648
Re: C8 Temperature gauge/sensor problems
This is the wiring between the Temp coolant Sensor (1220) and the Engine ECU (1320). Given that you have had 3 sensors - I would be suspecting the plug or the wiring to the engine ECU. I would suggest taking the connectors off the sensor - checking to see if the pins are making good contact (sometimes they can retract causing an intermittent connection) and then clean them up.
The Sensor plug should be a 2 pin green plug with the following wires:
4000: Coolant Temperature Sensor Earth (Pin 1)
400: Coolant Temperature info (Pin 2)
They go to the engine ECU 48 pin Brown plug on pins D1 and E1
This is the location of the earthing points - so I would check the MC15 and MC12 earths which both concern the engine ECU. Make sure they're not rusty or making poor contact.
Click Diagram to Zoom
The Sensor plug should be a 2 pin green plug with the following wires:
4000: Coolant Temperature Sensor Earth (Pin 1)
400: Coolant Temperature info (Pin 2)
They go to the engine ECU 48 pin Brown plug on pins D1 and E1
This is the location of the earthing points - so I would check the MC15 and MC12 earths which both concern the engine ECU. Make sure they're not rusty or making poor contact.
Click Diagram to Zoom
Please Don't PM Me For Technical Help
Marc
Marc