On my walk.
Moderator: RichardW
-
- Donor 2023
- Posts: 13727
- Joined: 01 Apr 2012, 09:47
- Location: Reading
- My Cars: C5 Mk2 VTX+ estate.
- x 2993
Re: On my walk.
Good luck, Gibbo. It might well be worth getting the gearbox reconditioned first, as that will include changing the transmission fluid and fitting a reconditioned torque convertor, and should then let the gearbox go for 150,000 miles before it needs another major service.
James
ex BX 1.9
ex Xantia 2.0HDi SX
ex Xantia 2.0HDi LX
Ex C5 2.0HDi VTR
Ex C5 2.0HDi VTR
C5 2.2HDi VTX+
Yes, I am paranoid, but am I paranoid ENOUGH?
Out amongst the stars, looking for a world of my own!
ex BX 1.9
ex Xantia 2.0HDi SX
ex Xantia 2.0HDi LX
Ex C5 2.0HDi VTR
Ex C5 2.0HDi VTR
C5 2.2HDi VTX+
Yes, I am paranoid, but am I paranoid ENOUGH?
Out amongst the stars, looking for a world of my own!
- Paul-R
- Donor 2023
- Posts: 6916
- Joined: 07 May 2009, 16:24
- Location: Wirral, NW England; Vaucluse 84, France
- Lexia Available: Yes
- My Cars: 2015 1.6 Blue HDi 120 Peugeot 308 Active SW
2013 2.0 HDi 163 C5 Exclusive Tourer
2003 2.0 HDi 110 C5 Exclusive Estate (Gone)
2001 2.0 HDi 90 Xsara Estate (Gone) - x 1369
Re: On my walk.
I hope that for the sake of your sanity that all the little bits to go with auto box are either in the car or arrive with the replacement box. The chances are fairly high that you'll get to a point and find that there's some vital bit missing.
Good luck.
Good luck.
As I get older I think a lot about the hereafter - I go into a room and then wonder what I'm here after.
Inside every old person is a young person wondering what the hell happened.
"Trying is the first step towards failure" ~ Homer J Simpson
Inside every old person is a young person wondering what the hell happened.
"Trying is the first step towards failure" ~ Homer J Simpson
-
- (Donor 2020)
- Posts: 7171
- Joined: 08 Jun 2011, 18:04
- Location: GL15***
- My Cars: 2006 C5 2.0 Litre HDI VTR Automatic Estate.(now sold on)
Currently Renault Zoe 2014 ZE - x 2500
Re: On my walk.
You're probably not wrong there Paul but it's wait and see, I think most of the stuff is here and the box is coming from someone who's only just started breaking the car so hopefully anything missing will still be in his possession.
Man is, by nature, a lazy beast, he does not need twice encouraging to do nothing.
-
- (Donor 2020)
- Posts: 7171
- Joined: 08 Jun 2011, 18:04
- Location: GL15***
- My Cars: 2006 C5 2.0 Litre HDI VTR Automatic Estate.(now sold on)
Currently Renault Zoe 2014 ZE - x 2500
Re: On my walk.
Gearbox just arrived, a couple of days late (well it always is ) Courier said "it's heavy" "Yes" I said "93 kg according to the manual" "It says 35 kg on my load listing." says he.
Man is, by nature, a lazy beast, he does not need twice encouraging to do nothing.
-
- (Donor 2020)
- Posts: 1810
- Joined: 19 Jan 2015, 17:42
- Location: Congleton
- Lexia Available: Yes
- My Cars: '95 Xantia 1.9D automatic - 109k one of two remaining
'03 206 GTi180 - 97k in pieces being brought back up to snuff
'03 206 1.9TD - home-built veg-fuelled B-road bruiser
'99 306 SE 2.0i cabriolet - 92k awaiting service work ready for next summer
'97 306 XS 1.6i 3 door, Bianca White, from dead 12 years & seized solid to road legal in 7 days - x 212
Re: On my walk.
He should've listed it as 39kg, then at least he could claim dyslexia when the courier comes for the extra money
'95 Xantia LX 1.9D-auto, Black, 109k
'03 206 GTi180 94k in surgery
'03 206 1.1S XUD9TE/veg project
'99 306 2.0SE cabriolet 95k summer toy
'97 306 XS 1.6i 99k sat 12 years, fixed in 7 days, 150mile maiden voyage
'03 206 GTi180 94k in surgery
'03 206 1.1S XUD9TE/veg project
'99 306 2.0SE cabriolet 95k summer toy
'97 306 XS 1.6i 99k sat 12 years, fixed in 7 days, 150mile maiden voyage
-
- (Donor 2020)
- Posts: 7171
- Joined: 08 Jun 2011, 18:04
- Location: GL15***
- My Cars: 2006 C5 2.0 Litre HDI VTR Automatic Estate.(now sold on)
Currently Renault Zoe 2014 ZE - x 2500
Re: On my walk.
Lifted the box into place today...........they weren't kidding when they said it was heavy.....and awkward, a real sod to line up and close into position.
Seems I'm a few bolts short, or rather too long the bell housing bolts come in a multitude of types and lengths and they ain't all included in the goodies collected with the car.
Seems I'm a few bolts short, or rather too long the bell housing bolts come in a multitude of types and lengths and they ain't all included in the goodies collected with the car.
Man is, by nature, a lazy beast, he does not need twice encouraging to do nothing.
-
- Donor 2023
- Posts: 2625
- Joined: 24 May 2007, 10:11
- Location: poole dorset uk
- Lexia Available: Yes
- My Cars: C5 X7 2009 2.0 HDI VF7**************[VIN obfuscated, can be read by forum staff]
C4 2010 2.0 HDi Exclusive VF7**************[VIN obfuscated, can be read by forum staff] - x 378
Re: On my walk.
Okay i have been away for a few years but have i missed the update ?
- demag
- (Donor 2016)
- Posts: 1441
- Joined: 18 Oct 2004, 05:03
- Location: Black Country, aye it ar kid.
- My Cars: "H" Citroen Bx Tgs Automatic.
2006 Toyota Prius T4 Gen 2. - x 102
Re: On my walk.
Gibbo did you have another search in the field just in case there are odd nuts and bolts about?
Dave
2011 Peugeot 3008 1.6hdi Exclusive EGS.
'04 C5 auto estate 2.2 hdi. Gone.
Bx 1.6 TGS Auto 50k A rare beast by all accounts. A bit tired but getting better by the day. Gone.
'96 XM 2.5TD VSX.......Sadly sold. What an idiot! I should have held on to that.
2011 Peugeot 3008 1.6hdi Exclusive EGS.
'04 C5 auto estate 2.2 hdi. Gone.
Bx 1.6 TGS Auto 50k A rare beast by all accounts. A bit tired but getting better by the day. Gone.
'96 XM 2.5TD VSX.......Sadly sold. What an idiot! I should have held on to that.
-
- (Donor 2020)
- Posts: 7171
- Joined: 08 Jun 2011, 18:04
- Location: GL15***
- My Cars: 2006 C5 2.0 Litre HDI VTR Automatic Estate.(now sold on)
Currently Renault Zoe 2014 ZE - x 2500
Re: On my walk.
Box is all fitted, had a bit of a problem with no fuel coming up, it was the primer bulb holed so replaced that, Citroen only supply it as a part with the whole dual pipeline so it had to be an Ebay aftermarket part adapted to fit.
Had to lower the suspension by the bleed off valve because it didn't want to do anything through the controls, when about half a litre was out the pump started so it looks as though that's not going to be a problem
Turned the key and it fired up, no problem with the engine it seems despite not being run for near four years.
Set up the date and time stuff on the display.
Put the left hand drive shaft in yesterday but keep getting rained off so it's going to have to wait now until probably Wednesday before I can do any more.
You don't need to drain the gearbox on these for the drive shaft jobs they've designed it so it's sealed.
Brakes will need cleaning up, rusty disks etc. but they're not badly worn and the pads have plenty of meat left on them.
The bolts were all there Dave once I was able to sort out the sizes.
Had to lower the suspension by the bleed off valve because it didn't want to do anything through the controls, when about half a litre was out the pump started so it looks as though that's not going to be a problem
Turned the key and it fired up, no problem with the engine it seems despite not being run for near four years.
Set up the date and time stuff on the display.
Put the left hand drive shaft in yesterday but keep getting rained off so it's going to have to wait now until probably Wednesday before I can do any more.
You don't need to drain the gearbox on these for the drive shaft jobs they've designed it so it's sealed.
Brakes will need cleaning up, rusty disks etc. but they're not badly worn and the pads have plenty of meat left on them.
The bolts were all there Dave once I was able to sort out the sizes.
Man is, by nature, a lazy beast, he does not need twice encouraging to do nothing.
- demag
- (Donor 2016)
- Posts: 1441
- Joined: 18 Oct 2004, 05:03
- Location: Black Country, aye it ar kid.
- My Cars: "H" Citroen Bx Tgs Automatic.
2006 Toyota Prius T4 Gen 2. - x 102
Re: On my walk.
That's brilliant news well done.
Dave
2011 Peugeot 3008 1.6hdi Exclusive EGS.
'04 C5 auto estate 2.2 hdi. Gone.
Bx 1.6 TGS Auto 50k A rare beast by all accounts. A bit tired but getting better by the day. Gone.
'96 XM 2.5TD VSX.......Sadly sold. What an idiot! I should have held on to that.
2011 Peugeot 3008 1.6hdi Exclusive EGS.
'04 C5 auto estate 2.2 hdi. Gone.
Bx 1.6 TGS Auto 50k A rare beast by all accounts. A bit tired but getting better by the day. Gone.
'96 XM 2.5TD VSX.......Sadly sold. What an idiot! I should have held on to that.
- CitroJim
- A very naughty boy
- Posts: 49532
- Joined: 30 Apr 2005, 23:33
- Location: Paggers
- My Cars: Bluebell the AX, Polly the C3 Picasso, Pix the Nissan Pixo, Propel the duathlon bike, TCR Pro the road bike and Fuji the TT bike...
- x 6163
- Contact:
Re: On my walk.
Excellent result Gibbo
Jim
Runner, cyclist, time triallist, duathlete, Citroen AX fan and the CCC Citroenian 'From A to Z' Columnist...
Runner, cyclist, time triallist, duathlete, Citroen AX fan and the CCC Citroenian 'From A to Z' Columnist...
- van ordinaire
- (Donor 2017)
- Posts: 2537
- Joined: 23 Jun 2015, 14:45
- Location: Live & work in London but weekend in Devon (or do I now live in Torbay & work in London?)
- My Cars: Citroens:-
'81 2CV Club (quietly sleeping in a parallel universe)
'05 (yes, really) C15
'97 Xantia Exclusive estate
others:-
'96 Jeep Cherokee Limited - the "donor"
'99 Jeep Cherokee Orvis - the green one
'97 Jeep Cherokee Limited - the red one
'99 Cadillac Seville STS
'96 Cadillac Eldorado ETC
& numerous what might be described as abandoned projects! - x 405
Re: On my walk.
Some guys have all the luck - but no more than you deserve for taking the job on in the first place!
Citroens:-
'81 2CV Club
'05 C15
'97 Xantia Exclusive estate
others:-
Jeep XJ Cherokees x 3
'96 Cadillac Eldorado
'99 Cadillac STS
& the numerous "abandoned projects"
'81 2CV Club
'05 C15
'97 Xantia Exclusive estate
others:-
Jeep XJ Cherokees x 3
'96 Cadillac Eldorado
'99 Cadillac STS
& the numerous "abandoned projects"
- CitroJim
- A very naughty boy
- Posts: 49532
- Joined: 30 Apr 2005, 23:33
- Location: Paggers
- My Cars: Bluebell the AX, Polly the C3 Picasso, Pix the Nissan Pixo, Propel the duathlon bike, TCR Pro the road bike and Fuji the TT bike...
- x 6163
- Contact:
Re: On my walk.
van ordinaire wrote: ↑07 Aug 2017, 00:15 Some guys have all the luck - but no more than you deserve for taking the job on in the first place!
No arguing with that I totally agree...
Jim
Runner, cyclist, time triallist, duathlete, Citroen AX fan and the CCC Citroenian 'From A to Z' Columnist...
Runner, cyclist, time triallist, duathlete, Citroen AX fan and the CCC Citroenian 'From A to Z' Columnist...
-
- (Donor 2020)
- Posts: 7171
- Joined: 08 Jun 2011, 18:04
- Location: GL15***
- My Cars: 2006 C5 2.0 Litre HDI VTR Automatic Estate.(now sold on)
Currently Renault Zoe 2014 ZE - x 2500
Re: On my walk.
Thanks for the comments....the luck may yet change though It hasn't been dropped onto its wheels and given a run and that second hand gearbox from a breaker could yet turn into a dud. Fingers crossed.
Man is, by nature, a lazy beast, he does not need twice encouraging to do nothing.
-
- Donor 2023
- Posts: 13727
- Joined: 01 Apr 2012, 09:47
- Location: Reading
- My Cars: C5 Mk2 VTX+ estate.
- x 2993
Re: On my walk.
STOP BEING SO BL00DY PESSIMISTIC!! She will live again, she WILL live again, SHE WILL LIVE AGAIN (and as a decent mode of transport and not as a baked bean tin!).
James
ex BX 1.9
ex Xantia 2.0HDi SX
ex Xantia 2.0HDi LX
Ex C5 2.0HDi VTR
Ex C5 2.0HDi VTR
C5 2.2HDi VTX+
Yes, I am paranoid, but am I paranoid ENOUGH?
Out amongst the stars, looking for a world of my own!
ex BX 1.9
ex Xantia 2.0HDi SX
ex Xantia 2.0HDi LX
Ex C5 2.0HDi VTR
Ex C5 2.0HDi VTR
C5 2.2HDi VTX+
Yes, I am paranoid, but am I paranoid ENOUGH?
Out amongst the stars, looking for a world of my own!