Xantiaq headlamp/relay Mod
Moderator: RichardW
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Xantiaq headlamp/relay Mod
Would like to update the main feeds for the headlamps (got my projector lens', so need to make good high power relay feeds) and I can't find a diagram.............is there one on the forum ?
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Re: Xantiaq headlamp/relay Mod
If you only want to by-pass the main switch for main and dipped beam you will need 2 relays ~20Amp each.
The modification is at fusebox in engine compartment and you will feed the bulbs from battery +
The modification is at fusebox in engine compartment and you will feed the bulbs from battery +
- chinkostu
- Posts: 1180
- Joined: 24 Sep 2014, 09:41
- Location: cheshire
- My Cars: N Xantia 1.9TD SX
03 Fiesta 1.4 Zetec - x 30
Re: Xantiaq headlamp/relay Mod
Get a 4 pin relay (not sure on exact name but the ones that run the fans are the same), run a nice thick guage from terminal 30 to the battery or fusebox live and run 85 to ground. Be sure to use a fused wire for the positive!
Now, what I do is trigger the relay from the original wiring using a scotchlock as it pulls minimal current just switching a relay, you'll have to figure out which is positive and earth though. Then terminal 87 run a nice fat wire to the lamp. You only need thick wires for these as the original wiring is only triggering the relay and the bulbs will be running off of the new wiring.
You'll be best then taking the earth from the lamp and running a thicker wire from there to a decent ground on the car. You will probably be able to run both lowbeams from one relay if your wire is thick enough (i ran 2 spotlights on a previous car this way) however you won't be able to run mains and low from one relay for obvious reasons
Now, what I do is trigger the relay from the original wiring using a scotchlock as it pulls minimal current just switching a relay, you'll have to figure out which is positive and earth though. Then terminal 87 run a nice fat wire to the lamp. You only need thick wires for these as the original wiring is only triggering the relay and the bulbs will be running off of the new wiring.
You'll be best then taking the earth from the lamp and running a thicker wire from there to a decent ground on the car. You will probably be able to run both lowbeams from one relay if your wire is thick enough (i ran 2 spotlights on a previous car this way) however you won't be able to run mains and low from one relay for obvious reasons
Stu
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
- DickieG
- Monaco's youngest playboy
- Posts: 4877
- Joined: 25 Nov 2006, 09:15
- Location: Buckinghamshire
- My Cars:
- x 38
Re: Xantiaq headlamp/relay Mod
This link explains the benefit of carrying out a headlamp relay mod very well complete with wiring diagrams.
13 Ram 1500 Hemi
14 BMW 535D Tourer
19 BMW i3s
06 C3 Desire 1.4
72 DS 21 EFi Pallas BVH
14 BMW 535D Tourer
19 BMW i3s
06 C3 Desire 1.4
72 DS 21 EFi Pallas BVH
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
Found this only a few mins away....all standard stuff then, good. Learnt to check even the "simple" things with Citroen....plus I am as self confident as a mouse in a cats home when it comes to my spannering....thanks for the assistance chaps.DickieG wrote:This link explains the benefit of carrying out a headlamp relay mod very well complete with wiring diagrams.
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
- chinkostu
- Posts: 1180
- Joined: 24 Sep 2014, 09:41
- Location: cheshire
- My Cars: N Xantia 1.9TD SX
03 Fiesta 1.4 Zetec - x 30
Re: Xantiaq headlamp/relay Mod
You can also buy the relay prewired with decent lengths at halfords/motoring shops, not sure how much more they are.
Stu
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
I have all the relays from the two scrap cars...I am sure they will be in there...and a Motor factors to assist avoiding Fraudfords
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
- chinkostu
- Posts: 1180
- Joined: 24 Sep 2014, 09:41
- Location: cheshire
- My Cars: N Xantia 1.9TD SX
03 Fiesta 1.4 Zetec - x 30
Re: Xantiaq headlamp/relay Mod
Good good when you break the wiring diagram down its actually really simple, if you can find the elusive twin 87 relay it makes wiring a smidge easier, otherwise you have to try and crimp two wires into one spade which can be snug!
A crimper or solder and soldering iron wouldn't go amiss either!
A crimper or solder and soldering iron wouldn't go amiss either!
Stu
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
Cars
1995 Xantia 1.9TD SX in (faded) Red
2003 Fiesta 1.4 Zetec in GREEEEEEEN
2001 206 1.9 LX
2001 Saxo VTR
1999 Saxo 1.1 East coast
1999 Punto
1996 306 1.8 XN Auto
1996 Fiesta 1.3
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
All will be soldered for sure, I hate crimps and scotch blocks more than I hate Chelsea, Man-U and Justin Bieber added together.
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Re: Xantiaq headlamp/relay Mod
You'll be adding Aston Villa to that lot on the 30th May..
Sent from my SM-N9005 using Tapatalk
Sent from my SM-N9005 using Tapatalk
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
Well all I can say is LeBoss is doing his stuff again.. weeeee are on a roll again mate .....and how much have the others spent over the last 10 years ?
.....really tho, Villa are trying hard atm, fair play to them.
.....really tho, Villa are trying hard atm, fair play to them.
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Re: Xantiaq headlamp/relay Mod
And how much, apart from one FA cup, did you win over the last nine years?Stickyfinger wrote:Well all I can say is LeBoss is doing his stuff again.. weeeee are on a roll again mate .....and how much have the others spent over the last 10 years
Sent from my SM-N9005 using Tapatalk
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
We won the Best Stadium in the UK, no billion pound loans and Europe every year, always top 4 and a sprinkle of silver......jealous ? ........Northern_Mike wrote:And how much, apart from one FA cup, did you win over the last nine years?Stickyfinger wrote:Well all I can say is LeBoss is doing his stuff again.. weeeee are on a roll again mate .....and how much have the others spent over the last 10 years
Sent from my SM-N9005 using Tapatalk
edit....LOL....the use of We...as if I did anything to help...
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Re: Xantiaq headlamp/relay Mod
West Ham have got the best stadium and you've just confirmed that you've not actually won anything A team made up from FCFers could have won as many trophies or promotions as Arsenal did for 9 yearsStickyfinger wrote:We won the Best Stadium in the UK, no billion pound loans and Europe every year, always top 4 and a sprinkle of silver......jealous ? ........Northern_Mike wrote:And how much, apart from one FA cup, did you win over the last nine years?Stickyfinger wrote:Well all I can say is LeBoss is doing his stuff again.. weeeee are on a roll again mate .....and how much have the others spent over the last 10 years
Sent from my SM-N9005 using Tapatalk
edit....LOL....the use of We...as if I did anything to help...
I'm both a Burnley fan (family thing we had shares since 1948!) and a closet Man U fan from years of living abroad and having to have an English team to support that was actually winning In Europe. So no, not jealous I think Man U and Burnley won a couple of things
Sent from my SM-N9005 using Tapatalk
- Stickyfinger
- (Donor 2016)
- Posts: 10411
- Joined: 28 Mar 2013, 21:05
- Location: Somset my lovleee
- My Cars: Xantia V6 ACTIVA 3ltr 24v Manual p1
Xm 2.1TD Ph2 Exclusive
AX, little Daffodil
SAXO White Mk1. Sally - x 1280
- Contact:
Re: Xantiaq headlamp/relay Mod
All about being "always there" with us Gooners, which ever way you look at it we are that.
Disagree about WestHam's new one.....not at all like the Family home at the Emirates, it will not have the atmosphere I think....Chairman at West Ham is switched on however with that price drop, She will cause a few ripples at Arsenal with our prices ....Sunderland on the 20th is my next trip up
Disagree about WestHam's new one.....not at all like the Family home at the Emirates, it will not have the atmosphere I think....Chairman at West Ham is switched on however with that price drop, She will cause a few ripples at Arsenal with our prices ....Sunderland on the 20th is my next trip up
Alasdair
Activa, the Moose Rider
3x C5x7 Steering racks and counting
Activa, the Moose Rider
3x C5x7 Steering racks and counting