heater motor on 2002 c5 will only work on full power
Moderator: RichardW
-
- Posts: 99
- Joined: 22 May 2013, 11:24
- Location: newcastle, staffs
- My Cars: citroen c5 2007 and 2002 c5 hdi
- x 1
heater motor on 2002 c5 will only work on full power
hi my heater fan motor will only work on full power c 5 hdmi 2002 any info please
C5 2007 HDI
- myglaren
- Forum Admin Team
- Posts: 25482
- Joined: 02 Mar 2008, 13:30
- Location: Washington
- My Cars: Mazda 6
Ooops.
Previously:
2009 Honda Civic :(
C5, C5, Xantia, BX, GS, Visa.
R4, R11TXE, R14, R30TX - x 4922
Re: heater motor on 2002 c5 will only work on full power
Has it standard aircon or is it climate control?
- waynedance
- Posts: 973
- Joined: 29 May 2011, 22:56
- Location:
- My Cars:
- x 8
Climate control if it has it will be the heater resistor to the left of the clutch pedal (if manual gears).
Not sure if standard manual aircon has the resistor in the same place.
Not sure if standard manual aircon has the resistor in the same place.
Volvo S80 D5.........
C5 2.2HDi Exclusive 2003 manual (now gone).
2009 Renault Megane, the misses drive.
Had a 1988 BX 19TRS Auto many moons ago.
Forgive any spelling mistakes, it's the phone not me.
C5 2.2HDi Exclusive 2003 manual (now gone).
2009 Renault Megane, the misses drive.
Had a 1988 BX 19TRS Auto many moons ago.
Forgive any spelling mistakes, it's the phone not me.
-
- Posts: 99
- Joined: 22 May 2013, 11:24
- Location: newcastle, staffs
- My Cars: citroen c5 2007 and 2002 c5 hdi
- x 1
Re: heater motor on 2002 c5 will only work on full power
its standard airconmyglaren wrote:Has it standard aircon or is it climate control?
C5 2007 HDI
- myglaren
- Forum Admin Team
- Posts: 25482
- Joined: 02 Mar 2008, 13:30
- Location: Washington
- My Cars: Mazda 6
Ooops.
Previously:
2009 Honda Civic :(
C5, C5, Xantia, BX, GS, Visa.
R4, R11TXE, R14, R30TX - x 4922
Re: heater motor on 2002 c5 will only work on full power
Don't know where the resistor pack is for that but it will be the fusible link (overheat sensor) that has gone, not an uncommon problem for many cars, not just PSA.
It is possible to replace the link, Maplin's, and many other electronics sources will have them.
The difficult bit is fixing them in place. They are crimped in as the heat of a soldering iron would kill them.
Likely to look like this:
These are for the climate control models:
'Resistor' in question will be similar to this:
I have a vague idea that they are in the passenger footwell/centre tunnel. Someone who really knows will be along eventually with better information.
It is possible to replace the link, Maplin's, and many other electronics sources will have them.
The difficult bit is fixing them in place. They are crimped in as the heat of a soldering iron would kill them.
Likely to look like this:
These are for the climate control models:
'Resistor' in question will be similar to this:
I have a vague idea that they are in the passenger footwell/centre tunnel. Someone who really knows will be along eventually with better information.
-
- Posts: 99
- Joined: 22 May 2013, 11:24
- Location: newcastle, staffs
- My Cars: citroen c5 2007 and 2002 c5 hdi
- x 1
-
- Posts: 8061
- Joined: 30 Dec 2004, 23:10
- Location: Somewhere in North Wales, Anglesey
- My Cars: M reg Xm S2 2.1td Auto Exclusive. 269k and rising
L reg XM S1 V6 12v Manual SEi
L 94 XM 2.1 TD auto total resto
2008 Peugeot 207 Sw 1.6 16v hdi. 217k and rising
2010 Peugeot 207 SW 1.6 8v HDi 161k and rising - x 71
Re: heater motor on 2002 c5 will only work on full power
Is the car an LX with 4 speed fan contoller??
IF SO then the plug to the resister would of over heated and given a bad connection. The resister on base LX models is on the passenger side..
I did a post on it I think on here with mine, But what I actually did was cut the plug off and soldered the wires directly to the resister..
The actual resister was perfectly fine!!!
IF SO then the plug to the resister would of over heated and given a bad connection. The resister on base LX models is on the passenger side..
I did a post on it I think on here with mine, But what I actually did was cut the plug off and soldered the wires directly to the resister..
The actual resister was perfectly fine!!!
Sharing a pug 207 1.6 hdi Sw 16v.
M reg Xm 2.1 td auto exclusive S2 269k and rising
L reg XM V6 12v SEi auto .. Light project
A very sad...
1994 XM 2.1 d auto
M reg Xm 2.1 td auto exclusive S2 269k and rising
L reg XM V6 12v SEi auto .. Light project
A very sad...
1994 XM 2.1 d auto