Evening Guys,
what are the perrils and pitrfalls of doing the Rocker gasket on the td lump??
will grab one next week and get it done, been leaking a little since mot, anything i need to look out for particularly??
put the new Aux belt on this week which was easier than i expected!!! feeling in good car tinkering spirits at the mo!!
many thanks in advance,
Timmo.
Xantia 1.9TD rocker gasket change
Moderator: RichardW
- Timmo
- (Donor 2022)
- Posts: 1346
- Joined: 11 Jul 2011, 15:41
- Location: Bottom Left!
- My Cars: 58 partner teepee outdoor hdi.
58 C2 Code in black! Fun! - x 168
- Contact:
Xantia 1.9TD rocker gasket change
After All, I am the Cornish one!
'58 C2 Code
'58 partner teepee outdoor
'58 C2 Code
'58 partner teepee outdoor
-
- Posts: 8061
- Joined: 30 Dec 2004, 23:10
- Location: Somewhere in North Wales, Anglesey
- My Cars: M reg Xm S2 2.1td Auto Exclusive. 269k and rising
L reg XM S1 V6 12v Manual SEi
L 94 XM 2.1 TD auto total resto
2008 Peugeot 207 Sw 1.6 16v hdi. 217k and rising
2010 Peugeot 207 SW 1.6 8v HDi 161k and rising - x 71
Re: Xantia 1.9TD rocker gasket change
Remove inlet intercooler pipes and remove the small inlet intake steel pipe 2x 13mm nuts.. break the seal.. you can then get at it.. 3x 10mm bolts and lift it off.. theres no need to remove the full inlet you can squeeze it past the inlet this way...
fit and re assemble.. ...use a slight thin layer of instant goo on the inlet steel pipe when re fitting...
fit and re assemble.. ...use a slight thin layer of instant goo on the inlet steel pipe when re fitting...
Sharing a pug 207 1.6 hdi Sw 16v.
M reg Xm 2.1 td auto exclusive S2 269k and rising
L reg XM V6 12v SEi auto .. Light project
A very sad...
1994 XM 2.1 d auto
M reg Xm 2.1 td auto exclusive S2 269k and rising
L reg XM V6 12v SEi auto .. Light project
A very sad...
1994 XM 2.1 d auto
- Timmo
- (Donor 2022)
- Posts: 1346
- Joined: 11 Jul 2011, 15:41
- Location: Bottom Left!
- My Cars: 58 partner teepee outdoor hdi.
58 C2 Code in black! Fun! - x 168
- Contact:
Re: Xantia 1.9TD rocker gasket change
thnk you!
After All, I am the Cornish one!
'58 C2 Code
'58 partner teepee outdoor
'58 C2 Code
'58 partner teepee outdoor
- Timmo
- (Donor 2022)
- Posts: 1346
- Joined: 11 Jul 2011, 15:41
- Location: Bottom Left!
- My Cars: 58 partner teepee outdoor hdi.
58 C2 Code in black! Fun! - x 168
- Contact:
Re: Xantia 1.9TD rocker gasket change
What a blimmen Ball ache that job was!!!! Crikey, popped the inelt pipes off and the air pipe off the corner as one of the vacumn hoses had come off, but could i get the cover out!!! the metal pipe retainer clips on the back of the housing gave no end of grief, especially as i couldnt get a socket on it, the ring end of the spanner was loose on it and could only get the open end of for an 1/8th turn each time!!!! got it out and was simple then!! went back together a lot easier!! even managed not to have any left over parts!!!!
old cover was the original looking at it, Rock hard!! and the gearbox end bolt was loose which no doubt didnt help the slight oil loss out that side!!
will get some degreaser up on it and wash it off so its clean and easier to spot whats where dreckly!!
old cover was the original looking at it, Rock hard!! and the gearbox end bolt was loose which no doubt didnt help the slight oil loss out that side!!
will get some degreaser up on it and wash it off so its clean and easier to spot whats where dreckly!!
After All, I am the Cornish one!
'58 C2 Code
'58 partner teepee outdoor
'58 C2 Code
'58 partner teepee outdoor
- Xaccers
- Posts: 7654
- Joined: 07 Feb 2007, 23:46
- Location: Milling around Milton Keynes
- My Cars:
- x 184
Re: Xantia 1.9TD rocker gasket change
Sorry you had trouble with it. I find it helps if when you've removed the three retaining bolts (and pushed the coolant pipe down the back of it out the way, you just lift it up a little bit, slide it to the side so one of the "dips" on the rear edge matches up with the inlet pipe, then rotate it out by lifting the back edge up.
1.9TD+ SX Xantia Estate (Cassy) running on 100% veg
1.9TD SX Xantia Hatchback (Jenny) running on 100% veg for sale
Laguna II 2.0dCi Privilege (Monty)
DIY sphere tool
1.9TD SX Xantia Hatchback (Jenny) running on 100% veg for sale
Laguna II 2.0dCi Privilege (Monty)
DIY sphere tool
- Timmo
- (Donor 2022)
- Posts: 1346
- Joined: 11 Jul 2011, 15:41
- Location: Bottom Left!
- My Cars: 58 partner teepee outdoor hdi.
58 C2 Code in black! Fun! - x 168
- Contact:
Re: Xantia 1.9TD rocker gasket change
I tried every conceivable way to get it out without taking the clips off but it wouldn't come out!!
After All, I am the Cornish one!
'58 C2 Code
'58 partner teepee outdoor
'58 C2 Code
'58 partner teepee outdoor