Another intermittant interior fan?

Our most popular forum is for Citroën problems, discussions and chat.
Specialising in AX, BX, ZX, Xantia,C5, Xsara, Saxo and XM. CX, 2cv & Berlingo, all are welcome.NOT for selling cars/parts!

Moderator: RichardW

Chris Peddie
Posts: 50
Joined: 29 Apr 2001, 17:04
Location:
My Cars:

Another intermittant interior fan?

Postby Chris Peddie » 29 Aug 2002, 01:28

Hello all,
My interior fan (or blower motor, depending where you're from) has become intermittant again ('96 TDLX with A/C). The ignition switch, being the obvious answer was replaced not long ago when the problem last surfaced so isn't likely to be the cause. Wiggling the key doesn't help.
So, what is the next most likely answer?? Assuming I don't find a bad contact when I take it apart, I'm think that after 129k of operation the brushes on the motor might be a bit tired. Failing this it could be the air-con version of a rheostat (sp?), mounted on the fan itself. Obviously I would prefer it to be the brushes!!! (=cheap fix) The problem might also have resulted from a leaking windscreen (which will move outwards when I push from the inside - is this normal????) soaking the fan assembly in a downpour!!
Anyone have any opinions/experience on this??
Cheers,
Chris
0 x

NiSk
Posts: 1435
Joined: 24 Jan 2002, 21:11
Location: Sweden
My Cars:

Postby NiSk » 29 Aug 2002, 18:09

If you have the simple version of the A/C (i.e. not ECC)then a common fault is the two drive transistors for the fan. They are darlington pairs and burn out if you are unlucky. They sit on a circuit board behind the control panel. I think Radiospares can match them.
//NiSk
0 x

Chris Peddie
Posts: 50
Joined: 29 Apr 2001, 17:04
Location:
My Cars:

Postby Chris Peddie » 29 Aug 2002, 19:16

Thanks for your response, your suggestion does make sense - I do have the simple A/C version (thankfully) and it only becomes intermittant when in the auto position, if set manually it works ok!
I'll add this to my list of potential causes and check it out!
0 x

Chris Peddie
Posts: 50
Joined: 29 Apr 2001, 17:04
Location:
My Cars:

Postby Chris Peddie » 09 Sep 2002, 17:16

Noticed today that the air con compressor cuts out when the fan goes off as well, and comes on again when the fan comes on again - does this happen with transistor failure??
Haven't had a chance to examine them yet!!
Chris
0 x


Return to “Citroën”

Who is online

Users browsing this forum: Bing [Bot] and 9 guests