C5 X7 Would failed radiator fan prevent aircon from working?

Post your Cit/Peu/Ren air conditioning queries or advice.

Moderator: RichardW

mikevybiral
Posts: 17
Joined: 02 Jul 2015, 07:44

C5 X7 Would failed radiator fan prevent aircon from working?

Post by mikevybiral » 02 Jul 2015, 08:42

C5 X7 2.0 HDI 2008
Diagbox shows aircon OK (clutch OK, pressure OK)
Clutch fails to engage when AC button pressed.
When clutch engaged (using direct connection to battery) the compressor gets v. hot (my spit boils on compressor after 4 mins).
Just found the single radiator cooling fan has failed (open circuit across power connection).
Would this prevent the clutch engaging?
Also, what is the role of the smaller pins on the cooling fan motor?
Comments welcome.
Thanks,
Mike

User avatar
DickieG
Monaco's youngest playboy
Posts: 4892
Joined: 25 Nov 2006, 10:15

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by DickieG » 02 Jul 2015, 16:41

Yes it will and the compressor is getting so hot due to excess pressure building up in the system because the heat in the gas not being dissipated through the condenser (A/C radiator) which in turn causes the system to over-pressurise and switch off to prevent damaging the system so personally I wouldn't run the A/C until the fan is repaired.

mikevybiral
Posts: 17
Joined: 02 Jul 2015, 07:44

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by mikevybiral » 04 Jul 2015, 00:12

Just replaced fan assembly.
Aircon now works.
Thanks for contribution.
Mike

User avatar
Stickyfinger
Donor 2016
Posts: 9741
Joined: 28 Mar 2013, 22:05

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by Stickyfinger » 04 Jul 2015, 00:40

Where did you source your fan from ?, I may be in the same situation

mikevybiral
Posts: 17
Joined: 02 Jul 2015, 07:44

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by mikevybiral » 04 Jul 2015, 06:55

Bought new fan assembly (from NEAT on eBay) for £250.
Suggest you
1. Check relay (in box to R on fan) first.
2. Confirm fan u/s by disconnecting cables in box and removing relay. Then connect battery voltage directly to large feed connector and short out large relay sockets with a short length of garden wire. Alternatively, remove fan assembly, disconnect cables from motor, then connect 12V directly to large socket on motor.
NB1 no need to remove bumper.
NB2 don't close bonnet with no bonnet release cable connected!
Get back to me if you need more info.
Mike

User avatar
DickieG
Monaco's youngest playboy
Posts: 4892
Joined: 25 Nov 2006, 10:15

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by DickieG » 04 Jul 2015, 07:34

mikevybiral wrote:NB2 don't close bonnet with no bonnet release cable connected!

Something tells me there's a story there,,,, :lol:

mikevybiral
Posts: 17
Joined: 02 Jul 2015, 07:44

Re: C5 X7 Would failed radiator fan prevent aircon from work

Post by mikevybiral » 04 Jul 2015, 07:53

Just for once I saw it coming!
Made a temporary garden wire release loop through the grille.
Actually, it works quite well. I'll leave it for a while, just so people can say 'What's that ...?'
Mike